Browsing by Subject "Horse manure"

Now showing 1 - 1 of 1

Untersuchungen zur Verwertbarkeit von Pferdemist im Biogasprozess
(2014) Mönch-Tegeder, Matthias; Jungbluth, Thomas
The increasing use of energy crops as the main feedstock and the resulting occupancy of arable land is the central point of criticism of the population in biogas production. Although waste and residues provide significant energy potentials, the conversion of these materials in the biogas process has not been established to date. Significant barriers are the widely varying composition of these materials and their substrate properties. In general, the residues contain a high percentage of fiber, which rises great challenges for the existing process technology. This work aimed to address these challenges by investigating the suitability and usability of the fiber-rich substrate horse manure for biogas production in continuously operated agricultural biogas plants. The study was divided into three consecutive 1. Investigation of the composition and usability of horse manure with different bedding materials and determination of the specific methane yields also taking into account the aging process degradation of horse manure; 2. Determination of the impact of mechanical pretreatment of the substrate with the cross-flow grinder on the specific methane yield and degradation kinetics of commonly used energy crops and horse manure in laboratory-scale; 3. Studies on the feasibility of horse manure in full-scale biogas processes and the effects of mechanical treatment at the research biogas plant "Unterer Lindenhof”. The use of straw-based horse manure in the biogas process is feasible. However, contaminations with alternative bedding materials due to their low degradability must be avoided. Furthermore, a substantial loss of methane potential could be detected due to the storage and meanwhile aerobic degradation. As a result of the high dry matter content and low levels of essential micro- and macro-nutrients, horse manure should only be utilized in biogas plants with suitable co - substrates. The mechanical treatment of silage and horse manure with the cross-flow grinder resulted in a significant reduction in particle size and increased substrate surface. However, no significant changes in the specific methane yield of the investigated silages were observed. Due to the increase of the substrate surface the degradation rate of the grass silage and whole crop silage accelerates. The mechanical disintegration of horse manure resulted in a significant increase of the specific methane yield and a significant improvement of the degradation kinetics. When considering the energy balance of the disintegration, a positive result could only be obtained for the processing of the fiber-rich substrates. Accordingly a previous disintegration of silage for biogas production is not recommended. The results from the investigation of the usability of untreated and disintegrated horse manure in the full-scale biogas process show that the use of horse manure without previous treatment causes serious procedural problems and results in insufficient degrees of degradation. The mechanical pretreatment guarantees a plant operation without failures during this trial. Additionally a complete substrate utilization can be achieved due to the treatment. The additional energy expenditure for the operation of the cross flow grinder was overcompensated by the higher gas yield. The results of this study show, that with a suitable treatment technology, the use of straw based horse manure and other high fiber structural materials in agricultural biogas plants is possible. A complete conversion of straw based horse manure provides an energy equivalent of up to 156,000 ha of maize. Thus, this study helps to improve the sustainability and profitability of biogas production and the achievement of the energy policy objectives.